Optical, structural, morphological, and gas sensing properties of Mg-doped α-Fe₂O₃ thin films deposited by RF and DC magnetron Co-sputtering technique

In this research, Mg -doped hematite (alpha-Fe2O3) thin films with different Mg -doping concentrations were synthesized on glass substrates using the direct current (DC) and radio frequency (RF) magnetron co -sputtering technique, and the changes of some physical properties due to the concentration of the dopant were investigated. The optical, structural, morphological, and elemental properties of the obtained Mg -doped alpha-Fe2O3 thin films were determined by X-ray diffraction (XRD) analysis, UV-Vis spectroscopy, Raman spectroscopy, scanning electron microscopy (SEM), dispersive X-ray spectroscopy and atomic force microscopy (AFM). XRD analysis revealed that the investigated thin films have a rhombohedral crystal structure. The deposition of films at different DC sputtering voltages caused significant variations in stoichiometry and nanostructure. The thin films' band gap energy values were estimated based on absorption measurements, and results ranged from 2.15 eV to 2.69 eV. Raman peaks were observed between 218 cm(-1) and 1305 cm(-1). The thin films exhibit uniform surface morphology throughout the substrate according to the SEM images. The low RMS roughness values obtained from AFM images showed that the surfaces of Mg:Fe2O3 thin films are smooth. The Mg -doped alpha-Fe(2)O(3 )thin film doped by 150 W DC voltage exhibited a good gas -sensing response at 300 C. A remarkably quick response/ recovery time was achieved.

Dergi

PHYSICA B-CONDENSED MATTER

Yıl

2024

Cilt

677

ISSN

0921-4526

eISSN

1873-2135

DOI

10.1016/j.physb.2024.415704

WoS UID

WOS:001176199100001